Effect of Conversion Point Moisture Content on Quality of Dried <i>Macrobrachium rosenbergii</i> Meat during Vacuum Freezing Combined with Instant Controlled Pressure Drop Drying

CHENG Xiaoning; ZHANG Zhuo; ZHAO Ya; SHI Qilong; GAO Ruichang; JU Xiangdong

doi:10.13386/j.issn1002-0306.2024040352

Turn off MathJax

Article Contents

Abstract

References

CHENG Xiaoning, ZHANG Zhuo, ZHAO Ya, et al. Effect of Conversion Point Moisture Content on Quality of Dried Macrobrachium rosenbergii Meat during Vacuum Freezing Combined with Instant Controlled Pressure Drop Drying[J]. Science and Technology of Food Industry, 2025, 46(7): 1−10. (in Chinese with English abstract). doi: 10.13386/j.issn1002-0306.2024040352.

Citation:

PDF (5645 KB)

Effect of Conversion Point Moisture Content on Quality of Dried Macrobrachium rosenbergii Meat during Vacuum Freezing Combined with Instant Controlled Pressure Drop Drying

1.
College of Agricultural Engineering and Food Science, Shandong University of Technology, Zibo 255000, China
2.
College of Food and Biotechnology Engineering, Jiangsu University, Zhenjiang 212013, China
3.
Jiangsu Qiwu Aquatic Products Development Co., Ltd., Gaoyou 225600, China

More Information

Received Date: April 22, 2024
Available Online: February 07, 2025

Graphical Abstract

Abstract

Abstract

Aiming at solving the problem of high energy consumption in vacuum freeze drying (VFD), instant controlled pressure drop (DIC) was used due to its puffing capacity during drying in combination with VFD. The effect of different conversion point moisture content (60%, 50%, 40% and 30%) on the drying kinetics, microstructure and quality characteristics of dried Macrobrachium rosenbergii were investigated. The Macrobrachium rosenbergii meat with VFD alone was also carried out for comparison. The result showed that compared with VFD alone, the drying time was significantly shortened and drying efficiency improved. Compared to the products obtained from VFD alone, VFD-DIC produced a severely damaged structure, significant volume shrinkage and quality degradation when the conversion point moisture content was 60%. With the decrease of the conversion point moisture content, the quality of dried Macrobrachium rosenbergii meat gradually approached to products obtained with VFD alone. When the conversion point moisture content was 30%, the crude protein content, shrinkage rate and texture properties of Macrobrachium rosenbergii meat were not significantly different from those obtained from the VFD alone (P>0.05). Correlation analysis showed that transverse relaxation time was significantly correlated with the quality characteristics (P<0.05). Hierarchical cluster analysis showed that the quality of shrimp meat with the conversion point moisture content of 30% was in the same cluster as the CK. In conclusion, when the conversion point moisture content was 30%, the quality of VFD-DIC Macrobrachium rosenbergii meat was close to that of the VFD alone, but the drying efficiency was significantly enhanced. This study can provide theoretical basis and practical reference for high quality and efficient drying of Macrobrachium rosenbergii meat, especially VFD.
- Macrobrachium rosenbergii meat,
- freeze drying,
- instant controlled pressure drop,
- combined drying,
- quality characteristic

FullText(HTML)

References (34)

References

[1]	应宇斌. 鲤鱼鳞水解物对罗氏沼虾抗冻保护作用及其活性成分分析研究[D]. 杭州:浙江大学, 2022. [YING Yubin. Study on antifreeze protection and active components of hydrolysate of common carp scales on Macrobrachium rosenbergii[D]. Hangzhou:Zhejiang University, 2022.] YING Yubin. Study on antifreeze protection and active components of hydrolysate of common carp scales on Macrobrachium rosenbergii[D]. Hangzhou: Zhejiang University, 2022.
[2]	MIAO Shuyan, HU Juntao, WAN Wenlong, et al. Biofloc technology with addition of different carbon sources altered the antibacterial and antioxidant response in Macrobrachium rosenbergii to acute stress[J]. Aquaculture,2020,525:735280. doi: 10.1016/j.aquaculture.2020.735280
[3]	梁加越, 赵广华, 臧佳辰. 贝类水产品干燥技术研究进展[J]. 食品工业,2022,43(11):257−260. [LIANG Jiayue, ZHAO Guanghua, ZANG Jiachen. Research progress of drying technology of shellfish[J]. Food Industry,2022,43(11):257−260.] LIANG Jiayue, ZHAO Guanghua, ZANG Jiachen. Research progress of drying technology of shellfish[J]. Food Industry, 2022, 43（11）: 257−260.
[4]	GUO Xiujin, SHI Liu, XIONG Shanbai, et al. Gelling properties of vacuum-freeze dried surimi powder as influenced by heating method and microbial transglutaminase[J]. LWT-Food Science and Technology,2019,99:105−111. doi: 10.1016/j.lwt.2018.09.050
[5]	WEI H M, RASUL M G, SUN Z Q, et al. Study on mucleotide, myofibrillar protein biochemical properties and microstructure of freeze-dried scallop striated muscle during storage and rehydration[J]. Food Research International,2022,158:111461. doi: 10.1016/j.foodres.2022.111461
[6]	WU Jingna, PAN Nan, CHEN Xiaoting, et al. Comparative evaluation of physical characteristics and volatile flavor components of Bangia fusco-purpurea subjected to hot air drying and vacuum freeze-drying[J]. Current Research in Food Science,2023,7:100624. doi: 10.1016/j.crfs.2023.100624
[7]	MA Yaolan, XIONG Shanbai, YOU Juan, et al. Effects of vacuum chopping on physicochemical and gelation properties of myofibrillar proteins from silver carp (Hypophthalmichthys molitrix)[J]. Food Chemistry,2018,245:557−563. doi: 10.1016/j.foodchem.2017.10.139
[8]	NIU Jianzhen, ZHAO Binfan, GUO Xiujin, et al. Effects of vacuum freeze-drying and vacuum spray-drying on biochemical properties and functionalities of myofibrillar proteins from silver carp[J]. Journal of Food Quality,2019,2019:1−8.
[9]	LANDYMORE C, DURANCE T D, SINGH A, et al. Comparing different dehydration methods on protein quality of krill (Euphausia pacifica)[J]. Food Research International,2019,119:276−282. doi: 10.1016/j.foodres.2018.12.001
[10]	赵亚, 张越翔, 徐燕, 等. 不同预干燥方式对瞬时压差膨化香菇脆品质特性的影响[J]. 食品工业科技, 2023, 44(17):281−287. [ZHAO Ya, ZHANG Yuexiang, XU Yan, et al. Effect of different pre-drying methods on the quality attributes of instant controlled pressure drop puffing dried shiitake (Lentinus edodes) crisps[J]. Science and Technology of Food Industry, 2023, 44(17):281−287.] ZHAO Ya, ZHANG Yuexiang, XU Yan, et al. Effect of different pre-drying methods on the quality attributes of instant controlled pressure drop puffing dried shiitake （Lentinus edodes） crisps[J]. Science and Technology of Food Industry, 2023, 44（17）: 281−287.
[11]	LYU J, BI Jinfeng, WANG Fengzhao, et al. Recent developments and trends of instant controlled pressure drop drying-A review[J]. Drying Technology,2021,39(11):1704−1719. doi: 10.1080/07373937.2021.1916753
[12]	CHENG Xiaoning, ZHAO Ya, SHI Qilong, et al. Instant controlled pressure drop (DIC) as an effective pretreatment to intensify drying efficiency and enhance quality attributes of heat pump dried scallop adductors[J]. Innovative Food Science and Emerging Technologies,2024,94:103701. doi: 10.1016/j.ifset.2024.103701
[13]	SUI Xiaole, ZHAO Ya, ZHANG Xin, et al. Hydrocolloid coating pretreatment makes explosion puffing drying applicable in protein-rich foods–A case study of scallop adductors[J]. Drying Technology,2022,40(1):50−64. doi: 10.1080/07373937.2020.1768108
[14]	LIU Jing, ZHAO Ya, SHI Qilong, et al. Water distribution, physicochemical and microstructural properties of scallop adductors as affected by different drying methods[J]. Journal of Food Composition and Analysis,2023,115:104966. doi: 10.1016/j.jfca.2022.104966
[15]	国家卫生和计划生育委员会. 食品安全国家标准食品中水分的测定 GB5009.3-2016[S]. 北京:中国标准出版社, 2016. [National Health and Family Planning Commission. Food safety national standard food moisture determination GB5009.3-2016[S]. Beijing:Standards Press of China, 2016.] National Health and Family Planning Commission. Food safety national standard food moisture determination GB5009.3-2016[S]. Beijing: Standards Press of China, 2016.
[16]	WU Xiaotian, ZHAO Ya, SHI Qilong, et al. Effects of ethanol pretreatment on drying kinetics and quality attributes of scallop adductors during heat pump drying[J]. Drying Technology,2023,41(9):1514−1531. doi: 10.1080/07373937.2023.2166059
[17]	DENG Yun, LUO Yali, WANG Yuegang, et al. Drying-induced protein and microstructure damages of squid fillets affected moisture distribution and rehydration ability during rehydration[J]. Journal of Food Engineering,2014,123:23−31. doi: 10.1016/j.jfoodeng.2013.09.006
[18]	ZHANG Jiahui, ZHOU Dayong, ZHONG Xiaomin, et al. Quality and protein degradation of golden pompano (Trachinotus blochii) fillets during four drying methods[J]. LWT-Food Science and Technology,2020,130:109638. doi: 10.1016/j.lwt.2020.109638
[19]	杨慧, 吴洪斌, 贾文婷, 等. 基于品质分析的哈密瓜真空冷冻-变温压差膨化联合干燥工艺研究[J]. 保鲜与加工, 2022, 22(5):56−62. [YANG Hui, WU Hongbin, JIA Wenting, et al. Study on the combined drying process of cantaloupe by vacuum freezing and variable temperature pressure differential swelling based on quality analysis[J]. Preservation and Processing, 2019, 22(5):56−62.] YANG Hui, WU Hongbin, JIA Wenting, et al. Study on the combined drying process of cantaloupe by vacuum freezing and variable temperature pressure differential swelling based on quality analysis[J]. Preservation and Processing, 2019, 22（5）: 56−62.
[20]	任晗慈. 冻干联合膨化干燥银杏脆粒工艺优化及质地形成的研究[D]. 沈阳:沈阳农业大学, 2020. [REN Hanci. Study on optimization and texture formation of lyophilized and puffed-dried Ginkgo biloba Crisp Granules[D]. Shenyang:Shenyang Agricultural University, 2020.] REN Hanci. Study on optimization and texture formation of lyophilized and puffed-dried Ginkgo biloba Crisp Granules[D]. Shenyang: Shenyang Agricultural University, 2020.
[21]	CHENG Shasha, ZHANG Tan, YAO Li, et al. Use of low-field-NMR and MRI to characterize water mobility and distribution in pacific oyster (Crassostrea gigas) during drying process[J]. Drying Technology,2018,36(5):630−636. doi: 10.1080/07373937.2017.1359839
[22]	LI Min, GUAN Zhiqiang, GE Yunting, et al. Effect of pretreatment on water migration and volatile components of heat pump dried tilapia fillets[J]. Drying Technology,2020,38(14):1828−1842. doi: 10.1080/07373937.2019.1671449
[23]	任广跃, 朱乐雯, 段续, 等. 苹果冷冻-热风联合干燥体积收缩机制研究[J]. 农业工程学报,2024,40(2):63−71. [REN Guangyue, ZHU Lewen, DUAN Xu, et al. Study on volume shrinkage mechanism of apple combined freezing-hot air drying[J]. Transactions of the Chinese Society of Agricultural Engineering,2024,40(2):63−71.] doi: 10.11975/j.issn.1002-6819.202306182 REN Guangyue, ZHU Lewen, DUAN Xu, et al. Study on volume shrinkage mechanism of apple combined freezing-hot air drying[J]. Transactions of the Chinese Society of Agricultural Engineering, 2024, 40（2）: 63−71. doi: 10.11975/j.issn.1002-6819.202306182
[24]	HUANG Luelue, LIAN Miaomiao, DUAN Xu, et al. Studies on the quality and moisture distribution of kiwifruit dried by freeze drying combined with microwave vacuum drying[J]. Journal of Food Process Engineering,2021,44(1):e13581. doi: 10.1111/jfpe.13581
[25]	YI Jianyong, WANG Ping, BI Jinfeng, et al. Developing novel combination drying method for jackfruit bulb chips:Instant controlled pressure drop (DIC)-assisted freeze drying[J]. Food and Bioprocess Technology,2016,9:452−462. doi: 10.1007/s11947-015-1643-4
[26]	XU Huihuang, WU Min, WANG Bo, et al. Changes in water status and microstructure reveal the mechanisms by which tempering affects drying characteristics and quality attributes of medicinal chrysanthemums[J]. Industrial Crops and Products,2023,205:117463. doi: 10.1016/j.indcrop.2023.117463
[27]	HOU Yukun, XIA Songgang, MA Chengxin, et al. Effects of the soy protein to wheat gluten ratio on the physicochemical and structural properties of Alaska pollock surimi-based meat analogs by high moisture extrusion[J]. Food Research International,2023,173:113469. doi: 10.1016/j.foodres.2023.113469
[28]	REN Zhongyang, HUANG Xianglan, SHI Linfan, et al. Characteristics and potential application of myofibrillar protein from golden threadfin bream (Nemipterus virgatus) complexed with chitosan[J]. International Journal of Biological Macromolecules,2023,240:124380. doi: 10.1016/j.ijbiomac.2023.124380
[29]	JIANG Ning, LIU Chunquan, LI Dajing, et al. Evaluation of freeze drying combined with microwave vacuum drying for functional okra snacks:Antioxidant properties, sensory quality, and energy consumption[J]. LWT-Food Science and Technology,2017,82:216−226. doi: 10.1016/j.lwt.2017.04.015
[30]	罗静, 李敏, 关志强. 干燥工艺对罗非鱼片品质的影响[J]. 南方农业学报,2020,51(7):1764−1775. [LUO Jing, LI Min, GUAN Zhiqiang. Effect of drying process on quality of tilapia fillets[J]. Journal of Southern Agriculture,2020,51(7):1764−1775.] doi: 10.3969/j.issn.2095-1191.2020.07.032 LUO Jing, LI Min, GUAN Zhiqiang. Effect of drying process on quality of tilapia fillets[J]. Journal of Southern Agriculture, 2020, 51（7）: 1764−1775. doi: 10.3969/j.issn.2095-1191.2020.07.032
[31]	El HAJJ R, MHEMDI H, KHASHAYAR S, et al. Impact of instant controlled pressure drop texturing on the drying of yellow mealworms[J]. Journal of Insects as Food and Feed,2023,9(11):1523−1541. doi: 10.1163/23524588-20230027
[32]	赵亚, 吴小恬, 石启龙. 乙醇耦合其他预处理提高扇贝柱热泵干燥速率及品质[J]. 农业工程学报,2024,40(2):72−81. [ZHAO Ya, WU Xiaotian, SHI Qilong. Enhancing the heat pump drying rate and quality attributes of scallop adductors using ethanol coupled with other pre-treatments[J]. Transactions of the Chinese Society of Agricultural Engineering,2024,40(2):72−81.] doi: 10.11975/j.issn.1002-6819.202307182 ZHAO Ya, WU Xiaotian, SHI Qilong. Enhancing the heat pump drying rate and quality attributes of scallop adductors using ethanol coupled with other pre-treatments[J]. Transactions of the Chinese Society of Agricultural Engineering, 2024, 40（2）: 72−81. doi: 10.11975/j.issn.1002-6819.202307182
[33]	YU Dawei, FENG Tianyi, JIANG Qixing, et al. The change characteristics in moisture distribution, physical properties and protein denaturation of slightly salted silver carp (Hypophthalmichthys molitrix) fillets during cold/hot air drying processing[J]. LWT-Food Science and Technology,2021,137:110466. doi: 10.1016/j.lwt.2020.110466
[34]	LIU Jing, ZHAO Ya, SHI Qilong. Correlation of viscoelastic properties with water status of scallop adductors during heat pump drying:Effects of ultrasound pretreatment and drying conditions[J]. Food and Bioprocess Technology, 2024, doi:10.1007/s11947-024-03424-x (in press).

Supplements (0)

Get Citation

PDF

XML

Article Metrics

Article views (23) PDF downloads (7)

Science and Technology of Food Industry

Effect of Conversion Point Moisture Content on Quality of Dried Macrobrachium rosenbergii Meat during Vacuum Freezing Combined with Instant Controlled Pressure Drop Drying

Abstract

References

Catalog

Article Metrics

Export File

Citation

Format

Content